Design and Implementation of a Three-Phase Asynchronous Motor Drive Based on a Single Chip Three-Phase Bridge Driver IR 2132

Derian Endo Amandus; Slamet Riyadi; Leonardus Heru Pratomo

Authors

Derian Endo Amandus Soegijapranata Catholic Univercity
Slamet Riyadi Soegijapranata Catholic University
Leonardus Heru Pratomo Soegijapranata Catholic University

Keywords:

Asynchronous motor, Three-phase inverter, SPWM

Abstract

Technological developments in this world are growing quite rapidly, one of which is the development of the use of electric motors. There are many types of electric motors today, for example asynchronous electric motors or often called induction motors. In its use, asynchronous motors are widely used on an industrial scale. As time went by, asynchronous motor control itself also began to develop, starting from mechanically using switches to using inverters. The use of a three-phase IGBT inverter to control a three-phase asynchronous motor will be discussed in this research. The inverter control itself will use the SPWM topology, where the SPWM topology has advantages over the PWM topology. Apart from that, this research will use a single chip three-phase bridge driver IR2132 as the IGBT driver. This IC has advantages, one of which is that it has an internal deadtime, where deadtime is very necessary in controlling the three-phase inverter so that short circuits do not occur between the legs. This research shows that with a certain DC Link input voltage, it is possible to regulate a three-phase asynchronous motor using SPWM topology to control an IGBT inverter.

Downloads

Download data is not yet available.

Author Biographies

Slamet Riyadi, Soegijapranata Catholic University

Slamet Riyadi was born in Semarang-Indonesia, in 1967. He received B.Eng. degree from Diponegoro University, Semarang in 1991. M.Eng. and PhD degrees from Bandung Institute of

Technology, Bandung-Indonesia in 1997 and 2006. He also did PhD Partial Research in ENSEEIHT-INPT Toulouse, France in 2004. Currently, he is with the Department of Electrical

Engineering, Soegijapranata Catholic University, Semarang - Indonesia as a lecturer and researcher. His current researches are focused on electric drives, PV-Grid systems, power factor correction techniques and active power filtering. Some of his researches were supported by ASEM duo-France, The Ministry of Research and Technology - Indonesia, The Directorate General of Higher Education-Ministry of National Education - Indonesia, etc.

Leonardus Heru Pratomo, Soegijapranata Catholic University

Leonardus Heru Pratomo was born in Ambarawa-Indonesia, in 1976. He

received the B. Eng degree from Catholic University, Semarang-Indonesia in 1994

and M. Eng degree from Bandung Institute of Technology, Bandung-Indonesia in

In 2016, he received the Ph. D degree in Electrical Engineering from Gadjah

Mada University, Jogjakarta-Indonesia. Currently, he is a Lecturer and Researcher

at the Electrical Engineering Department at Soegijapranata Catholic University,

Semarang, Indonesia since 2000. Now. His research interest is focused on multilevel

inverter topology, grid-tie inverter, and renewable energy.

References

Institut Teknologi Bandung. Fakultas Teknologi Industri. Instrumentation and Control Research Group, Institute of Electrical and Electronics Engineers. Indonesia Section, Institute of Electrical and Electronics Engineers. Indonesia Section. CSS/RAS Joint Chapter, and Institute of Electrical and Electronics Engineers, Proceedings of the 2019 6th International Conference on Instrumentation, Control, and Automation (ICA)?: Bandung, Indonesia, 31 July - 2 August 2019.

Maha?witthaya?lai Songkhla?nakharin. College of Computing, C. Electrical Engineering/Electronics, IEEE Thailand Section, and Institute of Electrical and Electronics Engineers, The 17th International Conference on Electrical Engineering/Electronics, Computer, Telecommunications and Information Technology?: ECTI-CON 2020?: 24-27 June 2020, virtual conference hosted by College of Computing, Prince of Songkla University.

JCT College of Engineering and Technology and Institute of Electrical and Electronics Engineers, Proceedings of the 4th International Conference on Inventive Systems and Control (ICISC 2020)?: 8-10 January, 2020.

R. Pandey, A. K. Panda, and N. Patnaik, “Comparative Performance Analysis of DTC fed Three-Phase and Five-Phase Induction Motor,” in ICDCS 2020 - 2020 5th International Conference on Devices, Circuits and Systems, Institute of Electrical and Electronics Engineers Inc., Mar. 2020, pp. 162–166. doi: 10.1109/ICDCS48716.2020.243572.

A. Sudaryanto et al., “Design and Implementation of SVPWM Inverter to Reduce Total Harmonic Distortion (THD) on Three Phase Induction Motor Speed Regulation Using Constant V/F,” in 2020 3rd International Seminar on Research of Information Technology and Intelligent Systems, ISRITI 2020, Institute of Electrical and Electronics Engineers Inc., Dec. 2020, pp. 412–417. doi: 10.1109/ISRITI51436.2020.9315353.

B. S. S. G. Yelamarthi and S. R. Sandepudi, “Scalar Control of Induction Motor Drive with Inverter Fault-Tolerance Capability,” in 2020 International Conference on Emerging Frontiers in Electrical and Electronic Technologies, ICEFEET 2020, Institute of Electrical and Electronics Engineers Inc., Jul. 2020. doi: 10.1109/ICEFEET49149.2020.9187013.

B. Benhala, Ja?mi?at al-Mawla?y Isma??i?l. Faculty of Sciences, Institute of Electrical and Electronics Engineers. Morocco Section, and Institute of Electrical and Electronics Engineers, IRASET’2020?: 2020 1st International Conference on Innovative Research in Applied Science, Engineering and Technology (IRASET)?: March 19-20, 2020, Faculty of Sciences, Meknes University of Moulay Ismail - Morocco.

2018 International Conference on Smart Electric Drives and Power System (ICSEDPS). IEEE.

J. W. Rengifo and J. M. Aller, “An efficiency estimation method for inverter fed induction motors,” in Proceedings - 2021 IEEE Workshop on Electrical Machines Design, Control and Diagnosis, WEMDCD 2021, Institute of Electrical and Electronics Engineers Inc., Apr. 2021, pp. 22–27. doi: 10.1109/WEMDCD51469.2021.9425682.

R. Sarker, A. Datta, and S. Debnath, “FPGA-Based High-Definition SPWM Generation with Harmonic Mitigation Property for Voltage Source Inverter Applications,” IEEE Trans Industr Inform, vol. 17, no. 2, pp. 1352–1362, Feb. 2021, doi: 10.1109/TII.2020.2983844.

V. V. Kharlamov, Y. V. Moskalev, and V. S. Lysenko, “Simulation of the Electrical Phase Converter Connecting a Three-Phase Motor to A Single-Phase Network,” in 14th International IEEE Scientific and Technical Conference Dynamics of Systems, Mechanisms and Machines, Dynamics 2020 - Proceedings, Institute of Electrical and Electronics Engineers Inc., Nov. 2020. doi: 10.1109/Dynamics50954.2020.9306160.

Institute of Electrical and Electronics Engineers, SPEEDAM 2020 - proceedings?: International Symposium on Power Electronics, Electrical Drives, Automation and Motion?: virtual meeting, June 24th-June 26th.

T. V, Vellore Institute of Technology, Institute of Electrical and Electronics Engineers. Madras Section, IEEE Communications Society., and Institute of Electrical and Electronics Engineers, Conference proceedings, International Conference on Vision Towards Emerging Trends In Communication and Networking (ViTECoN 2019)?: 30-31, March 2019, Vellore, Tamilnadu, India.

R. K. Antar, N. S. Sultan, and A. J. Ali, “Speed Control of Three-Phase Induction Motor Fed by Renewable Energy Source,” in 2nd International Conference on Electrical, Communication, Computer, Power and Control Engineering, ICECCPCE 2019, Institute of Electrical and Electronics Engineers Inc., Feb. 2019, pp. 7–12. doi: 10.1109/ICECCPCE46549.2019.203739.

M. Mahbub, “Comparative Analysis of Five Different PWM Techniques on Three-Phase Voltage Source Inverter fed Induction Motor Drive,” in International Conference on Robotics, Electrical and Signal Processing Techniques, 2021, pp. 6–11. doi: 10.1109/ICREST51555.2021.9331234.

I. M. Al-Adwan and Y. A. Al Shiboul, “Effect of the Modulation Index and the Carrier Frequency on the Output Vol Tage Waveform of the Spwm Voltage Source Inverter,” in Proceedings of the 17th International Multi-Conference on Systems, Signals and Devices, SSD 2020, Institute of Electrical and Electronics Engineers Inc., Jul. 2020, pp. 960–968. doi: 10.1109/SSD49366.2020.9364104.

A. Ben Rhouma and M. Hamouda, “DSP Implementation of a Novel SPWM Algorithm Dedicated to the Delta Inverter,” in Proceedings - STA 2020: 2020 20th International Conference on Sciences and Techniques of Automatic Control and Computer Engineering, Institute of Electrical and Electronics Engineers Inc., Dec. 2020, pp. 195–200. doi: 10.1109/STA50679.2020.9329297.

P. N. Astya, M. Singh, Institute of Electrical and Electronics Engineers, Institute of Electrical and Electronics Engineers. Uttar Pradesh Section, and Sharda University. School of Engineering and Technology, IEEE 2019 International Conference on Computing, Communication, and Intelligent Systems (ICCCIS)?: proceedings?: on 18th-19th Oct, 2019.

2019 International Seminar on Application for Technology of Information and Communication (iSemantic). IEEE, 2019.